QUEST

KODIAK

LOGBOOKS

NEWSROOM

CUSTOMER CARE | Pubs Status, Service Notifications, and Warranty Support

Click here for a KODIAK warranty form.

Click here for a current KODIAK Publication listing and current revision status index

MANDATORY SERVICE BULLETINS

Document
Title
Effective Date
Revision
Compliance Effectivity
Status
FLAP SYSTEM, Flap Actuation; Mandatory Inspection Procedures
06/01/2010
B
MANDATORY
All KODIAK 100 Series Aircraft
ACTIVE
FUEL SYSTEM; Mandatory Fuel Drain Valve Replacement
09/16/2008
A
 MANDATORY All KODIAK 100 Series Aircraft.
AMENDED
Amendment to: FUEL SYSTEM; Mandatory Fuel Drain Valve Replacement
10/03/2008
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0005
ACTIVE
FUEL SYSTEM; Low Fuel Sensor Replacement
12/15/2008
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0007
ACTIVE
ELECTRICAL; Potentiometer Replacement
1/26/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009
ACTIVE
FUSELAGE; Mandatory Inspection
2/17/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009
ACTIVE
LANDING GEAR; MAIN GEAR CROSS TUBES INSPECTION
4/7/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009
ACTIVE
AMSAFE MANDATORY INERTIA REEL TEST
4/7/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0012
ACTIVE
FUEL SYSTEM; Mandatory Fuel Drain Valve Resistance Test
04/14/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0005
ACTIVE
GARMIN AHRS VIBRATION TEST
4/20/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009
ACTIVE
FUSELAGE; VERTICAL TAIL BOLT INSPECTION
06/09/2009
B
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009
ACTIVE
FLIGHT SURFACES; ADJUSTMENT
06/07/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0003
ACTIVE
FUEL SYSTEM; MANDATORY INSPECTION (WING)
07/09/2009
B
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009
ACTIVE
ELECTRICAL SYSTEM; GENERATOR CIRCUIT BREAKER CHECK PROCEDURE
06/12/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0012
ACTIVE
FUEL SYSTEM; DOUBLER RING SCREW INSPECTION
07/17/09
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0011 thru 100-0017
ACTIVE
MAIN LANDING GEAR; GREASE FITTINGS INSPECTION AND SPECIAL PRECAUTIONS.
07/15/2009
B
 MANDATORY All KODIAK 100 Series Aircraft
ACTIVE
FLAP SYSTEM; FLAP DRIVE ACTUATOR REPLACEMENT
06/01/2010
B
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0018
ACTIVE
FUEL SYSTEM; RESERVE FUEL BLADDER INSPECTION
07/21/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0018
ACTIVE
FUEL SYSTEM; MANDATORY CHAFE PROTECTION ADDITION TO MAIN CABIN FUEL LINES
7/31/2009
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0019
ACTIVE
CARGO DOOR; NOTICE REGARDING CARGO DOOR WINDOWS
07/08/2010
B
 MANDATORY All KODIAK 100 Series Aircraft
ACTIVE
FUSELAGE; MISSING FASTENERS
10/16/2009
A
 MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0014
ACTIVE
MAIN LANDING GEAR; BRAKE LINE ADJUSTMENT
09/11/2009
A
 MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0022
ACTIVE
PITOT STATIC SYSTEM; MANDATORY MODIFICATION
10/30/2009
A
 MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0022
ACTIVE
ELECTRICAL SYSTEM; Main Power Feed Cable
12/01/2009
A
 MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0029
ACTIVE
MANDATORY GARMIN G1000 SOFTWARE UPGRADE TO GDU VERSION 10.01
12/10/2009
B
 MANDATORY All KODIAK 100 Series Aircraft currently using GARMIN 9.03 software. System Software Version 0552.04will be displayed in the upper right corner of the MFD splash screen.
ACTIVE
ELEVATOR TRIM CONTROL SYSTEM; Mandatory Visual Inspection
11/12/2009
A
 MANDATORY KODIAK 100 Series Aircraft,100-0013 thru 100-0015 and 100-0017 thru 100-0018
ACTIVE
ELECTRICAL SYSTEM; Main Wiring Harness
11/25/2009
A
 MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0023
ACTIVE
ELECTRICAL SYSTEM; Main and Essential Bus Fuse Inspection
01/26/2010
A
 MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0032
ACTIVE
FATIGUE; AFT FUSELAGE RIVET INSPECTION AND DOUBLER INSTALLATION
03/08/2010
A
MANDATORY
 This Service Bulletin may be complied with as convenient for the owner/operator but must be completed prior to 1000
airframe hours.
ACTIVE
MANDATORY POH/AFM SUPPLEMENT ADDITION IN ACCORDANCE WITH KODIAK TCDS REVISION 10
03/03/2010
A
 MANDATORY KODIAK 100 Series Aircraft, 100-0035
ACTIVE
FLIGHT CONTROLS- Mandatory Balance Weight Inspection
03/03/2010
A
 MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0042
ACTIVE

SERVICE LETTERS

Document
Title
Effective Date
Revision
Compliance Effectivity Status
MAIN LANDING GEAR – Recommended Tire Inspection
7/10/2008
A
 RECOMENDED KODIAK 100 Series Aircraft,100-0001 thru 100-0003 ACTIVE
DOOR ASSEMBLY – New Latch Handle Assembly
7/18/2008
A
 RECOMENDED KODIAK 100 Series Aircraft,100-0001 thru 100-0005 ACTIVE
KODIAK 100 Series Pilot Operating Handbook- Revision 1.
08/15/2008
A
 INFORMATIVE KODIAK 100 Series Aircraft,100-0001 thru 100-0006 ACTIVE
COCKPIT; One-Time Pilots Side Control Pedestal Bolt Inspection
10/10/2008
A
 RECOMENDED KODIAK 100 Series Aircraft,100-0001, and 100-0004 thru 100-0006 ACTIVE
Temporary Loss of Attitude and Heading on Both Primary Flight Displays (PFD’s)
02/09/2009
A
 RECOMENDED All KODIAK 100 Series Aircraft

INACTIVE
(SEE SN-007)
FLIGHT CONTROLS; 22 Degree Elevator Change
04/21/2009
A
 RECOMENDED KODIAK 100 Series Aircraft, 100-0001 thru 100-0003 ACTIVE
Exhaust Stack Installation and Removal Instructions
05/06/2009
A
 INFORMATIVE All KODIAK 100 Series Aircraft ACTIVE
Instructions for Aircraft Field Modification of Cabin Light Time Delay Relay
05/22/2009
A
 RECOMENDED KODIAK 100 Series Aircraft, 100-0001 thru 100-0015 ACTIVE
PARACHUTE OPERATIONS; Installation Kit
06/11/2009
A
 INFORMATIVE All KODIAK 100 Series Aircraft ACTIVE
CONTROL COLUMN; Re-Index Sequence
05/07/2009
A
 RECOMENDED KODIAK 100 Series Aircraft, 100-0001 thru 100-0012 ACTIVE
CARGO DOOR; Window Replacement
07/02/2009
A
 RECOMENDED KODIAK 100 Series Aircraft, 100-0010 ACTIVE
Improvement for Aircraft; Seat Track Station Identification Markings
7/31/2009
A
 RECOMENDED KODIAK 100 Series Aircraft, 100-0001 thru 100-0019 ACTIVE
KODIAK Specific Repair Instructions; Indention on Horizontal Stabilizer
10/27/2009
A
 INFORMATIVE KODIAK 100 Series Aircraft, 100-0020 ACTIVE
Cargo Door Window Replacement
07/08/2010
A
 RECOMENDED KODIAK 100 Series Aircraft, 100-0003, 100-0004, 100-0006 thru 100-0022, and 100-0024 ACTIVE

SERVICE NOTIFICATIONS

Document
Title
Effective Date
Revision
Compliance Effectivity
Status
GARMIN LPV and LNAV / VNAV Approaches with Three Character Airport Identifiers.
07/29/2008
A
 Adhere to the directions specified in the attached
GARMIN Service Advisory.		 All G1000, Cirrus Perspective, G900X, G950, G600,
and GNS 400W/GNS 500W Series units are affected.
ACTIVE
Cold climate conditions may cause SVT Pathways to intercept the glide path at a higher
altitude than the published altitude.
01/21/2009
A
 All aircraft with GARMIN Integrated Flight Deck
systems with GDU Software v9.00 through v9.13
and Synthetic Vision Technology (SVT) installed are affected.		 Adhere to the directions specified in the attached
GARMIN Service Advisory.
ACTIVE
GARMIN G1000 System SD Card Incompatibility
04/7/2009
A
 Adhere to the directions specified in this service
notice.		 All KODIAK 100 Series Aircraft
ACTIVE
Fuel System Poppet Valve Notice
04/7/2009
A
 INFORMATIVE KODIAK 100 Series Aircraft, 100-0001 thru 100-0010
ACTIVE
Fuel Bladder Assembly Ring
04/12/2009
A
 INFORMATIVE KODIAK 100 Series Aircraft, 100-0001 thru 100-0010
ACTIVE
SBAS Operations in Australia, New Zealand and South Pacific Regions
05/29/2009
A
 Adhere to the directions specified in the attached
GARMIN Service Advisory.		 This Service Notice affects all Garmin G1000,
G900X, 6950, Perspective TM, Prodigy TM Integrated
Avionics Systems, 400W/500W Series and GNS
480 (CNX80) units with WAAS.
ACTIVE
Possible temporary loss of heading/attitude information in Garmin Integrated Flight
Deck and G600 Systems following extended power-on stall maneuvers
(Supersedes SL-005)
05/01/2009
A
 Adhere to the directions specified in the attached
GARMIN Service Advisory.		 All KODIAK 100 Series Aircraft
ACTIVE
Momentary failure indications (Red-X) can occur when deleting stored data
07/14/2009
A
 Adhere to the directions specified in the attached
GARMIN Service Advisory.		 All KODIAK 100 Series Aircraft with Garmin CDU
software version 9.14 or prior.
ACTIVE
Fuel System; Special Notice Regarding Maintenance on Reserve Fuel Bladder
07/14/2009
A
 INFORMATIVE All KODIAK 100 Series Aircraft
ACTIVE
GARMIN G1000; 0933 Revision A
07/31/2009
A
 Adhere to the directions specified in the attached
GARMIN Service Advisory.		 All KODIAK 100 Series Aircraft
ACTIVE
Special Air Worthiness Information Bulletin from the FAA
09/04/2009
A
 INFORMATIVE All KODIAK 100 Series Aircraft
ACTIVE
POH/AFM; Initial Release of 100-000-904 IR.
09/03/2009
A
 INFORMATIVE KODIAK 100 Series Aircraft operating with GARMIN
9.04 Software.
ACTIVE
POH-AFM; Placard Adjustments
09/11/2009
A
 Post pages in POH/AFM as described in the Action
Section of this Service Notice.		 All KODIAK 100 Series Aircraft
ACTIVE
Special Airworthiness Information Bulletin Pratt and Whitney Canada
10/15/2009
A
 Follow the recommendations of Pratt and Whitney
Document S.I.L. NO. GEN-091		 All KODIAK 100 Series Aircraft
ACTIVE
FOREIGN CERTIFICATION; KODIAK Requirements for Registration in Canada
10/01/2009
A
 See Background and Action section of this Service
Notice.		 KODIAK 100 Series Aircraft, 100-0001 thru 100-0026
ACTIVE
POH-AFM; Revisions 1, 2 and 3 Update Package
10/20/2009
A
 Post the pages attached to this Service Notification
in the POH/AFM and remove Temporary Revision
AFM-TR-IR-01, as described in the Action Section of
this Service Notice.		 ALL KODIAK 100 Series Aircraft currently using
POH/AFM 100-000-904
ACTIVE
GARMIN G1000; SERVICE ADVISORY 0944 REVISION A
10/15/2009
A
 Follow the recommendations of Garmin Service
Advisory No: 0944 Rev. A		 All KODIAK 100 Series Aircraft currently using
Garmin Software Version 9.04.
ACTIVE
INFORMATION NOTICE, CONTROL YOKE INTERCONNECT TURNBUCKLE THREAD
ENGAGEMENT
11/09/2009
A
 INFORMATIVE All KODIAK 100 Series Aircraft
ACTIVE
KODIAK AIRCRAFT MAINTENANCE MANUAL, REVISION 04 RELEASED
11/11/2009
A
 INFORMATIVE All KODIAK 100 Series Aircraft
ACTIVE
POH-AFM; TEMPORARY REVISION AFM-TR-04-01
12/04/2009
A
 INFORMATIVE All KODIAK 100 Series Aircraft
ACTIVE
GARMIN SERVICE BULLETIN 0823, REVISION C
12/07/2009
A
 Adhere to the directions specified in the attached
GARMIN Service Advisory.		 See GARMIN SERVICE ADVISORY
ACTIVE
GARMIN SERVICE ALERT 0824, REVISION C
12/07/2009
A
 Adhere to the directions specified in the attached
GARMIN Service Advisory.		 See GARMIN SERVICE ADVISORY
ACTIVE
POH-AFM; TEMPORARY REVISION AFM-TR-04-02
01/29/2010
A
 Post pages in POH/AFM as described in the Action section of this Service Notice. KODIAK 100 Series Aircraft, 100-0005
ACTIVE
TECHNICAL PUBLICATIONS DVD; REVISION 01 TO TP-2010-Q1
01/28/2010
A
 Replace previous Technical Publications DVD/Illustrated Parts Catalog with this new revision, TP-2010-Q1_Rev 01 All KODIAK 100 Series Aircraft
ACTIVE
KODIAK 100 CERTIFIED FOR INCREASE GROSS TAKEOFF WEIGHT (7255 LB) AND RAMP WEIGHT ( 7305 LB)
03/03/2010
A
 In order for serial numbers 100-0001 thru 100-0034 to utilize the increased gross weight, FSI-007 (Vortex Generator
Installation) must be ordered and installed. Once the retrofi t is complete, record compliance to FSI-007 (Vortex Generator
Installation) and SN-025 (increased gross weight 7255 LB) in the aircraft log book. The KODIAK POH/AFM Supplement 05
must be inserted into the KODIAK POH/AFM.		 All KODIAK 100 Series Aircraft
ACTIVE
G1000; GARMIN SERVICE ALERT 1001, REVISION A
02/08/2010
A
 Adhere to the directions specified in the attached
GARMIN Service Advisory.		 All Garmin G1000, G900X, PerspectiveTM, and ProdigyTM Integrated Flight Decks with the standby Navigation
Database option enabled and with GDU software versions 10.00 through 11.01.
ACTIVE
KODIAK POH/AFM 100-000-901 OBSOLETED
03/03/2010
A
 Dispose of the KODIAK 100 Series POH/AFM 100-000-901 in a way that would prevent further use of the material or duplication of any information. Add KODIAK POH/AFM Supplement 4; GARMIN G1000 GDU Software Version 6.14 to the KODIAK POH/AFM 100-000-904 manual. KODIAK 100 Series Aircraft equipped with GARMIN GDU Software Version 6.14 ACTIVE
KODIAK POH/AFM REVISION 05 RELEASE AND AIRCRAFT MAINTENANCE MANUAL REVISION 05 RELEASE
03/03/2010
A
 INFORMATIVE All KODIAK 100 Series Aircraft ACTIVE
POH-AFM; TEMPORARY REVISION AFM-TR-05-01
03/08/2010
A
 Post pages in POH/AFM as described in the Action section of this Service Notice. All KODIAK 100 Series Aircraft using 100-000-904 POH/AFM ACTIVE
AMM; TEMPORARY REVISION AMM-TR-05-01
03/08/2010
A
 Post pages in AMM as described in the Action section of this Service Notice. All KODIAK 100 Series Aircraft using AMM 490770. ACTIVE
TEMPORARY REVISION AFM-TR-05-02 and AMM-TR-05-02
05/05/2010
A
 Post pages in POH/AFM and AMM as described in the Action section of this Service Notice. All KODIAK 100 Series Aircraft using 100-000-904 POH/AFM and AMM 490770. ACTIVE
SN-032
 PENDING  
     
TEMPORARY REVISION AMM-TR-05-06 05/27/2010
A
 Post pages in AMM as described in the Action section of this Service Notice. All KODIAK 100 Series Aircraft using AMM 490770. ACTIVE
SN-034
 PENDING          
Aircraft Maintenance Manual Revision 06 Release 08/04/2010
A
 Post pages in AMM as described in the Action section of this Service Notice. All KODIAK 100 Series Aircraft using AMM 490770. ACTIVE
     
       
 
                   
HOME | CONTACT QUEST | SEND TO FRIEND | SITE MAP | SITE TOOLS